Product ID:FIX ALL GLOSS WHITE, K1301WZ
MSDS Date:09/18/1995
FSC:8010
NIIN:00N071584
MSDS Number: CBPCS

ZYNOLYTE PRODUCTS CO

2320 E DOMINGUEZ
CARSON, CA 90749
US

Emergency Phone: 303-623-5716

Info Phone: 310-513-0700

Preparer: JOHN R. KORDOSH

Cage: 25461

ZYNOLYTE PRODUCTS CO

6244 CARSON, CA 90749 US

Telephone: 310-513-0700

Cage: 25461

184 @ 68F

CAS: 67-64-1

RTECS: AL3150000

Fraction By Weight: 27%

OSHA PEL 1000 PPM

ACGIH TLV: 750 PPM; 1000 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

200 @ 100F

CAS: 74-98-6

RTECS: TX2275000

Fraction By Weight: 14%

OSHA PEL 1000 PPM

ACGIH TLV: ASPHYXIANT

15 @

CAS: 64742-89-8

Fraction By Weight: 11%

OSHA PEL N/K

ACGIH TLV: N/K

37 @ 100F

CAS: 106-97-8

RTECS: EJ4200000

Fraction By Weight: 10%

OSHA PEL 800 PPM

ACGIH TLV: 800 PPM

5.1 @ 68F

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 6%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM; 150 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

22 @ 68F

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 5%

OSHA PEL 200 PPM

ACGIH TLV: 50 PPM, S

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

72 @ 100F

CAS: 75-28-5

RTECS: TZ4300000

Fraction By Weight: 4%

OSHA PEL N/K

ACGIH TLV: N/K

0 @ 0F

CAS: 26813-14-9

Fraction By Weight: 2%

OSHA PEL N/K

ACGIH TLV: N/K

5.2

CAS: 64742-94-5

RTECS: WF3100000

Fraction By Weight: 1%

OSHA PEL N/K

ACGIH TLV: N/K

CONSULTATION FROM APPROPRIATE HEALTH PROFESSIONALS

RTECS: 9999999ZZ

INFO . REPORTS HAVE ASSOC RPTD & PRLNGD OVEREXP TO

RTECS: 9999999ZZ

STUDIES W/RATS HAVE SHOWN PETRO DISTILS CAUSE

RTECS: 9999999ZZ

IN SIMILAR STUDIES W/GUINEA PIGS, DOGS OR MONKEYS.

RTECS: 9999999ZZ

SHOWN A SIGNIFICANT INCREASE OF KIDNEY DMG OR AN

RTECS: 9999999ZZ

EATING/SMOKING. DO NOT STORE ABOVE 120F.

RTECS: 9999999ZZ

DIRECT SUNLIGHT TO AVOID BURSTING. DO NOT SPRAY

RTECS: 9999999ZZ

COATING W/OUT A NIOSH/MSHA APPROVED RESPIRATOR

RTECS: 9999999ZZ

EXHAUSTED. FOLLOW RESPIRATOR MANUFACTURER'S

RTECS: 9999999ZZ

LIMITS. USE ONLY EXPLOSION PROOF EQUIPMENT WITH

RTECS: 9999999ZZ

OF SPILL, SPLASH OR EXCESS OVERSPRAY. DO

RTECS: 9999999ZZ

IN THEM. PROTECTIVE CREAMS ARE NOT RECOMMENDED FOR

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHAL: MAY CAUSE NOSE & THROAT IRRIT.
MAY CAUSE NERVOUS SYS DEPRESS CHARACT BY FOLLOWING PROGRESSIVE
STEPS: HDCH, DIZZ, NAUS, STAG GAIT, LASSITUDE, LOSS OF
COORDINATION, CONFUSN, UNCON. SKIN/EYE CNTCT : MAY CAUSE IRRIT OR
BURNING OF EYES. RPTD/PRLNGD LIQ CNTCT MAY CAUSE SKIN IRRIT
W/DISCOMFORT & DERM. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: EYE WATERING, HDCH, NAUS, DIZZ, ETC
ARE SIGNS THAT SOLV LEVELS ARE TOO HIGH. SKIN ABSORPTION: SEE
INHAL. ORG SOLVS ARE EASILY ABSORBED. DRY SKIN, REDNESS OR DERM DUE
TO DEFAT ACTION OF SOLVS ARE SIGNS OF EXPOS. INGEST: SEE INHAL:MAY
ALSO RSLT IN GI DISTRESS. THERE IS DANGER OF PETRO DISTILS ENTERING
(SUPDAT)
Medical Cond Aggravated by Exposure:PREEXISTING EYE, SKIN AND
RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS
PRODUCT.

First Aid:INHAL: REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE ARTF RESP,
PREF MOUTH-TO-MOUTH. CALL MD. EYES: IMMED FLUSH W/PLENTY OF WATER
FOR AT LEAST 15 MIN; CALL MD. SKIN: WASH SKIN W/SOAP & WATER. IF
IRRIT OCCUR S, CNTCT MD. INGEST: CALL MD IMMED; HAVE NAMES OF
HAZARDOUS INGREDIENTS READY. DO NOT INDUCE VOMIT; KEEP HEAD LOWER
THAN WAIST. ASPIR OF VOMITUS MAY RSLT IN CHEM PNEUMONITIS &/OR
PULMONARY EDEMA.

Flash Point Method:TCC
Flash Point:-256F,-160C
Lower Limits:1%
Upper Limits:13%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . AVOID CONFINED SPACES. WATER MAY BE
UNSUITABLE AS AN EXTINGUISHING MEDIUM.
Unusual Fire/Explosion Hazard:VAPS ARE HVR/AIR & MAY ACCUM IN LOW AREAS
OF POOR VENT OR TRAVEL ALONG GROUND TO REMOTE IGNIT SITES. CONTENTS
ARE UNDER PRESS. KEEP COOL. EXPOS TO HEAT (SUPDAT)

Spill Release Procedures:VENTILATE AREA. REMOVE SOURCES OF IGNITION
INCLUDING HOT METAL SURFACES. WEAR APPROPRIATE CLOTHING AND GEAR.
PREVENT SKIN CONTACT AND AVOID BREATHING OF VAPOR. CONFINE
IMMEDIATELY AND REMOVE WITH INER T ABSORBENT SUCH AS CLAY OR SAND.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:OBSERVE LABEL PRECS. KEEP AWAY FROM
HEAT, SPKS & OPEN FLAME (IE ALL IGNIT SOURCES). CAP CNTNR AFTER
EACH USE. WASH THORO AFTER HANDLG & BEFORE(ING 16)
Other Precautions:AVOID UNNEC CNTCT. DO NOT TAKE INTERNALLY. DO NOT
PUNCTURE CNTNRS. USE W/ADEQ VENT - DO NOT INHALE VAPS. INTENTIONAL
MISUSE BY DELIB CONC & INHALING VAPS OF PROD MAY BE HARMFUL/FATAL.
DO NOT SAND, FLA ME CUT, BRAZE OR WELD DRY (ING 18)

Respiratory Protection:DO NOT BREATHE VAPS/MISTS. IF TLV, PEL OR OTHER
LIMS ARE EXCEEDED THEN WEAR PROPERLY FITTED VAP & PARTICULATE OR
POS PRESS AIR SUPPLIED RESP APPRVD BY NIOSH/MSHA FOR USE W/PAINTS
DURING APPLICATN & UN TIL ALL VAPS & SPRAY MISTS ARE (ING 19)
Ventilation:PROVIDE SUFFICIENT VENT IN VOL & PATTERN TO KEEP
CONTAMINANTS BELOW APPLIC OSHA REQS OR OTHER SUGGESTED EXPOS (ING
20)
Protective Gloves:NEOPRENE GLOVES OR BETTER.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
APRON, COVERALLS OR WORK CLOTHES. CHANGE CLOTHES & SHOES IN CASE
(ING 21)
Work Hygienic Practices:AS WITH ALL CHEMICAL PRODUCTS, USE CARE IN
HANDLING. DO NOT SMOKE OR EAT WITHOUT FIRST WASHING YOUR HANDS.
Supplemental Safety and Health
EXPLO HAZ: OR SUNLIGHT MAY CAUSE CANS TO BURST & PROPELL CONTENTS.
WATER FROM FOG NOZZS MAY BE HELPFUL IN COOLING UNRUPTURED CNTNRS TO
PVNT PRESS BUILDUP. EFTS OF OVEREXP: LUNGS IF SWALLOWED OR VOMITE D
& CAUSING INFLAM, DMG OR EVEN DEATH. CHRONIC: TOLUENE APPEARS ON
THE NAVY LIST OF OCCUP CHEM REPRO HAZS. SEEK (ING 11)

Boiling Pt:B.P. Text:>43F,>6C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:0.77 (H*2O=1)
VOC Grams/Liter:5.1
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:AEROSOL CAN.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS AND BASES, SELECTED AMINES.
Stability Condition to Avoid:NONE REASONABLY FORSEEABLE.
Hazardous Decomposition Products:MAY EMIT FUMES WHEN HEATED TO
DECOMPOSITION. MAY EMIT CARBON MONOXIDE, CARBON DIOXIDE,
UNIDENTIFIED ORGANIC COMPOUNDS.

Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GRUOND
WATER SYSTEMS. PLACE IN NON-LEAKING CONTAINERS. DISPOSE OF ABSORBED
MATERIAL IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL
REQUIREMENTS. DO NOT INCINERATE IN CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.